uthorization:
Login:
Password:
  















 

Detailed information

 

SUPPORT DESIGN USING UNWEDGE SOFTWARE FOR MINES OF NORNICKELS POLAR DIVISION



 The method of support design using Unwedge software is proposed and substantiated for mines of Nornickel’s Polar Division. The software allows rapid and qualitative stability analysis for roofs and sidewalls in underground excavations, as well as enables competent failure envelope plotting for an excavation or its area with regard to varying geological and geotechnical conditions, which improves safety and efficiency of mining. The article discusses two case-studies. The first event is roof fall along the system of joints in a development drive in the Kholbin Mine. In that case, the quantitative assessment of rock mass quality was never undertaken, thus, the systems of joints, sizes of wedges, contact conditions of joints, etc. were neglected. The second case describes the support design using Unwedge software for an excavation driven in rock mass of ramp RSH1/6-2 in the Oktyabrsky Mine. The excavation was supported as per the Unwedge design. The calculated safety factors for each rock wedge are higher than 2, which complies with Russian regulatory documents. The excavation stability is predicted for the operational period at the minimum risk of rock falls.


For citation:  Kosyreva M. A., Eremenko V. A., Gorbunova N. N., Tereshin A. A. Support design using Unwedge software for mines of Nornickel’s Polar Division. MIAB. Mining Inf. Anal. Bull. 2019;(8):5764. [In Russ]. DOI: 10.25018/0236-1493-2019-08-0-57-64.



: 8
2019
ISBN: 0236-1493
: 622.831; 622.2; 622.235
DOI: 10.25018/0236-1493-2019-08-0-57-64
Authors: Kosyreva M. A., Eremenko V. A., Gorbunova N. N., Tereshin A. A.

Authors' Information:
M.A. Kosyreva (1), Student, e-mail: marinkosyreva@gmail.com,
V.A. Eremenko, Dr. Sci. (Eng.), Professor of Russian Academy of Sciences,
Director of the Research Center Application of Geomechanics and Mining
of Convergent Technologies, Mining Institute, National University of Science
and Technology MISiS, 119049, Moscow, Russia, e-mail: prof.eremenko@gmail.com,
N.N. Gorbunova (1), Cand. Sci. (Eng.), Assistant Professor, e-mail: shedrinanata@mail.ru,
A.A. Tereshin (1), Cand. Sci. (Eng.), Assistant Professor, e-mail: tereshin_aa@rudn.ru,
1) Peoples Friendship University of Russia, Engineering Academy,
117198, Moscow, Russia.
Corresponding author: M.A. Kosyreva, e-mail: marinkosyreva@gmail.com.

Key words:
Support, support design, stability factor, rock wedges, systems of joints, excavation, rock bolt, shotcrete, mesh, Unwedge software, model calibration.

References:

1. Instruktsiya po vyboru tipa i parametrov krepi kapital'nykh, podgotovitel'nykh, nareznykh i ochistnykh vyrabotok v predel'no napryazhennom (ili oslablennom) blochnom massive rudnikov [Guidelines on support design selection for permanent, development preparatory and stoping drives in mines in ultimate-stress (or weakened) block rock mass. Nornickel’s Polar Division], Noril'sk, ZF OAO «GMK «Noril'skiy nikel'», 2018. [In Russ].


2. Rekomendatsii po krepleniyu i podderzhaniyu razvedochnykh, podgotovitel'nykh, nareznykh i ochistnykh vyrabotok na rudnikakh «Oktyabr'skiy», «Taymyrskiy», «Komsomol'skiy» i «Zapolyarnyy» [Recommendations on support and reinforcement of permanent, development, preparatory and stoping drives in the Oktyabrsky, Tiamyrsky, Komsomolsky and Zapolyarny Mines], Noril'sk, ZF OAO «GMK «Noril'skiy nikel'», 2014. [In Russ].


3. Ukazaniya po bezopasnomu vedeniyu gornykh rabot na Talnakhskom i Oktyabr'skom mestorozhdeniyakh, sklonnykh i opasnykh po gornym udaram [Safety guides for rockburst-hazardous mining at the Talnakh and Oktyarbsky deposits], Noril'sk, ZF OAO «GMK «Noril'skiy nikel'», 2015. [In Russ].


4. Eremenko V. A., Aynbinder I. I., Patskevich P. G., Babkin E. A. Rock mass assessment for mines of Nornickel’s Polar Division. Gornyy informatsionno-analiticheskiy byulleten’. 2017, no 1, pp. 5—17. [In Russ].


5. Louchnikov V. N., Eremenko V. A., Sandy M. P. Ground support liners for underground mines: energy absorption capacities and costs. Eurasian Mining. 2014. No 1.


6. Sidorov D. V., Kosukhin N. I., Shabarov A. N. Assessment of ore body stress state in mining in small-amplitude tectonic faulting zones. Gornyy informatsionno-analiticheskiy byulleten’. 2014, no 12, pp. 142—148. [In Russ].


7. Myaskov A. V. Current ecological-and-economic problems of subsoil management. Gornyy informatsionno-analiticheskiy byulleten’. 2014, no 2, pp. 157—160. [In Russ].


8. Timonin V. V., Kondratenko A. S. Process and measuring equipment transport in uncased boreholes. J. Min. Sci. 2015. Vol. 51, No 5, pp. 1056—1061.


9. Lushnikov V. N., Eremenko V. A., Sendi M. P., Kosyreva M. A. Selection of rock bolting for excavations in rockburst-hazardous mines. Fiziko-tekhnicheskiye problemy razrabotki poleznykh iskopayemykh. 2017, no 3, pp. 86—95. [In Russ].


10. Neugomonov S. S., Volkov P. V., Zhirnov A. A. Composite reinforcement of unstable rock mass using friction–type rock bolts SZA. Gornyy zhurnal. 2018, no 2, pp. 31—34. [In Russ].


11. Kalmykov V. N., Volkov P. V., Latkin V. V. Substantiation of composite steel bar/polymer material rock bolting pattern for full-scale testing in the Safyanov Mine. Aktual'nye problemy gornogo dela. 2016, no 2, pp. 27—35. [In Russ].


12. Akram Mian Sohail, Zeeshan Muhammad Rock Mass Characterization and Support Assessment along Power Tunnel of Hydropower in Kohistan Area, KPK, Pakistan. Journal of the geological society of India. 2018. Vol. 92. No 2. pp. 221—226.


13. Kazem Oraee, Nikzad Orae, Arash Goodarzi Effect of discontinuities characteristics on coal mine stability and sustainability. A rock fall prediction approach. International journal of mining science and technology. 2016. Vol. 26. No 1. pp. 65—70.


14. Li Z., Gong H., Zhang Y., Li P. Fracture Development Law and Its Influence on the Stability of Surrounding Rock of a Power Station Underground Plant. Journal of Jilin University (Earth Science Edition). 2018. Vol. 48. No 5. pp. 1574—1580.


15. Xiao H., Gong,H., Liu W., Wang Y., Zhao K. Axis Direction Optimization of Underground Power Plant Under Complicated Fractured Rock Mass Environment. Journal of Hunan University Natural Sciences. 2018. Vol. 45. No 25. pp. 41—45.


16. Eremenko V. A. Training courses on Map3D and Rockscience (Dips, RocData, Unwedge) for geomechanics (geotechnologists), geologists and mining engineers. Gornyy zhurnal. 2018, no 2, 2 p. [In Russ].


Back
Site map